Simulation study of wormhole formation and propagation during matrix acidizing of carbonate reservoirs using a novel in-situ generated hydrochloric acid

Abstract

Optimum acid selection based on reservoir condition is one of the key elements in achieving a successful treatment in carbonate matrix acidizing. High reaction and corrosion rate of regular hydrochloric acid especially in tight reservoirs with high temperatures is considered as a limitation of this acid. One alternative in a high-temperature reservoir is to use in-situ generated hydrochloric. The objective of this study is to simulate acidizing treatment using both regular hydrochloric and in-situ generated hydrochloric acid. A continuum two-scale model for linear and radial flow geometry was used to simulate dissolution pattern. A finite-volume method with an implicit backward Euler scheme was used to solve the governing equations. The results of the simulation in a linear system showed that, due to low face dissolution, the in-situ generated hydrochloric at low injection rates could create longer wormholes with less pore volume to breakthrough. The results also proved that using the in-situ generated hydrochloric acid could lead to less face dissolution and deeper penetration of acid into the reservoir. This acidizing system is very suitable in situations where a low injection rate is needed and regular hydrochloric cannot be used due to higher pore volume to breakthrough and high corrosion rate.

Cited as: Kiani, S., Jafari, S., Apourvari, S. N., Mehrjoo, H. Simulation study of wormhole formation and propagation during matrix acidizing of carbonate reservoirs using a novel in-situ generated hydrochloric acid. Advances in Geo-Energy Research, 2021, 5(1): 64-74, doi: 10.46690/ager.2021.01.07

References

Akanni, O. O. Mathematical modeling of wormhole propagation during matrix acidizing of carbonate reservoir. Texas, Texas A&M University, 2015.

Akanni, O. O., Nasr-El-Din, H. A. The accuracy of carbonate matrix-acidizing models in predicting optimum injection and wormhole propagation rates. Paper SPE 172575 Presented at SPE Middle East Oil & Gas Show and Conference, Manama, Bahrain, 8-11 March, 2015.

Aldakkan, B., Ahmed, M., Gomaa, J., et al. Low viscosity retarded acid system: A novel alternative to emulsified acids. Paper SPE 192175 Presented at SPE Kingdom of Saudi Arabia Annual Technical Symposium and Exhibition, Dammam, Saudi Arabia, 23-26 April, 2018.

Ali, M. T., Nasr-El-Din, H. A. A robust model to simulate dolomite-matrix acidizing. SPE Production & Operations, 2019, 34(1): 109-129.

Ali, M. T., Nasr-El-Din, H. A. New insights into carbonate matrix acidizing treatments a mathematical and experimental study. SPE Journal, 2020, 25(3): 1272-1284.

Al-Mutairi, S. H., Hill, A. D., Nasr-El-Din, H. A. Effect of droplet size, emulsifier concentration and acid volume fraction on the rheological properties and stability of emulsified acids. Paper SPE 107741 Presented at European Formation Damage Conference, Scheveningen, The Netherlands, 30 May-1 June, 2007.

Al-Mutairi, S. H., Nasr-El-Din, H. A., Hill, A. D. Effect of droplet size on the reaction kinetics of emulsified acid with calcite. SPE Journal, 2009, 14(4): 606-616.

Arslan, E., Sokhanvarian, K., Nasr-El-Din, H. A. Reaction rate of a novel in-situ generated HCl acid and calcite. Paper SPE 187059 Presented at SPE Annual Technical Conference and Exhibition, San Antonia, Texas, USA, 9-11 October, 2017.

Cairns, A. J., Al-Muntasheri, G. A., Sayed, M. Targeting enhanced production through deep carbonate stimulation: Stabilized acid emulsions. Paper SPE 178967 Presented at SPE International Conference and Exhibition on Formation Damage Control, Lafayette, Louisiana, USA, 24-26 February, 2016.

Chang, F., Nasr-El-Din, H. A. Matrix acidizing of carbonate reservoirs using organic acids and mixture of HCl and organic acids. Paper SPE 116601 Presented at SPE Annual Technical Conference and Exhibition, Denver, Colorado, USA, 21-24 September, 2008.

Cohen, C. E., Ding, D., Quintard, M., et al. From pore scale to wellbore scale: Impact of geometry on wormhole growth in carbonate acidization. Chemical Engineering Science, 2007, 63(12): 3088-3099.

Danckwerts, P. V. Continuous flow systems: Distribution of residence times. Chemical Engineering Science, 1953, 2(1): 1-13.

Fredd, C. N., Fogler, H. S. Influence of transport and reaction on wormhole formation in porous media. AIChE Journal, 1998, 44(9): 1933-1949.

Fredd, C. N. Dynamic model of wormhole formation demonstrates conditions for effective skin reduction during carbonate matrix acidizing. Paper SPE 59537 Presented at SPE Permian Basin Oil and Gas Recovery Conference, Midland, Texas, USA, 21-23 March, 2000.

Glasbergen, G., Kalia, N., Talbot, M. S. The optimum injection rate for wormhole propagation: myth or reality? Paper SPE 121464 Presented at the 8th European Formation Damage Conference, Scheveningen, The Netherlands, 27 May, 2009.

Golfier, F., Zarcone, C., Bazin, B. On the ability of a Darcyscale model to capture wormhole formation during the dissolution of a porous medium. Journal of Fluid Mechanics, 2002, 457: 213-254.

Kalia, N., Balakotaiah, V. Effect of medium heterogeneities on the reactive dissolution of carbonates. Chemical Engineering Science, 2009, 64(2): 2376-390.

Kalia, N., Glasbergen, G. Wormhole formation in carbonates under varying temperature conditions. Paper SPE 121803 Presented at the 8th European Formation Damage Conference, Scheveningen, The Netherlands, 27-29, May, 2009.

Kankaria, S., Nasr-El-Din, H. A., Rimassa, S. Matrix acidizing of carbonate rocks using new mixtures of HCl/methanesulfonic acid. Paper SPE 184528 Presented at SPE International Conference on Oilfield Chemistry, Montgomery, Texas, USA, 3-5 April, 2017.

Liu, P., Couples, G. D., Yao, J. A general method for simulating reactive dissolution in carbonate rocks with arbitrary geometry. Computational Geosciences, 2018, 22(5): 1187-201.

Liu, X., Ormond, A., Bartko, K. A geochemical reactiontransport simulator for matrix acidizing analysis and design. Journal of Petroleum Science and Engineering, 1997, 17(1-2): 181-196.

Mahmoud, M., Nasr-El-Din, H. A. Challenges during shallow and deep carbonate reservoirs stimulation. Journal of Energy Resources Technology, 2015, 137(1): 012902.

Mason, T. G., Bibette, J., Weitz, D. A. Yielding and flow of monodisperse emulsions. Journal of Colloid and Interface Science, 1996, 179(2): 439-448.

McDuff, D., Shuchart, C. E., Jackson, S. Understanding wormholes in carbonates unprecedented experimental scale and 3-D visualization. Paper SPE 134379 Presented at SPE Annual Technical Conference and Exhibition, Florence, Italy, 19-22 September, 2010.

Nasr-El-Din, H. A., Dana, H., Tomos, V. Field Treatment to stimulate an oil well in an offshore sandstone reservoir using a novel, low-corrosive, environmentally friendly fluid. Journal of Canadian Petroleum Technology, 2015, 54(5): 289-297.

Panga, M. K., Ziauddin, M., Balakotaiah, V. A new model for predicting wormhole structure and formation in acid stimulation of carbonates. Paper SPE 86517 Presented at SPE International Symposium and Exhibition on Formation Damage Control, Lafayette, Louisiana, 18-20 February, 2004.

Panga, M. K., Ziauddin, M., Balakotaiah, V. Two-scale continuum model for simulation of wormholes in carbonate acidization. AIChE Journal, 2005, 51(12): 3231-3248.

Shuchart, C. E., Gdanski, R. D. Improved success in acid stimulations with a new organic HF system. Paper SPE 36907 Presented at European Petroleum Conference, Milan, Italy, 22-24 October, 1996.

Sokhanvarian, K., Nasr-El-Din, H. A., de Wolf, C. A. Thermal stability of oilfield aminopolycrboxylic acids/salts. SPE Production & Operations, 2016, 31 (1): 12–21.

Sokhanvarian, K., Pummarapanthu, T., Arslan, E. A new insitu generated acid system for carbonate dissolution in sandstone and carbonate reservoirs. Paper SPE 184506 Presented at SPE International Conference on Oilfield Chemistry, Montgomery, Texas, USA, 3-5 April, 2017.

Yuan, T., Guan, Q. Numerical investigation of wormhole formation during matrix acidizing of carbonate rocks by coupling stokes-brinkman equation with reactive transport model under radial flow conditions. Paper SPE 199262 Presented at SPE International Conference and Exhibition on Formation Damage Control, Lafayette, Louisiana, USA, 19-21 February, 2020.