Mechanisms of reservoir pore/throat characteristics evolutionduring long-term waterflooding

Abstract

Formation pore structure and reservoir parameters change continually during waterflooding due to sand production, clay erosion, and pressure/temperature variation, which causes great challenge in geological modeling and simulation. In this work, the XA Oilfield, a block with more than 20 years’ waterflooding history, is used as an example to better understand the fundamental evolution mechanisms of reservoir pore network characteristics over long time waterflooding. We performed a large number of core analyses and experiments to obtain formation parameters (e.g., permeability, porosity, relative permeability, and etc.) at different development stages. The comparison illustrates that reservoir permeability can not only decrease with clay plugging, but also increase by the detachment of fine particles and even the destruction of microscopic structure. We also observed that the point/line contacts among grains decreases, the pore network connectivity increases, the clay content reduces and the rock trends to be more hydrophilic with increasing water injection. Moreover, we developed a pore network model to simulate the variation of formation parameter. The model parameters are also compared and analyzed to get a qualitative understanding of the evolvement laws, which will provide a useful guidance for reservoir accurate modeling.

Cited as: Wang, S., Han, X., Dong, Y., et al. Mechanisms of reservoir pore/throat characteristics evolution during long-term waterflooding. Advances in Geo-Energy Research, 2017, 1(3): 148-157, doi: 10.26804/ager.2017.03.02

References

Blunt, M.J., Bijeljic, B., Dong, H., et al. Pore-scale imaging and modelling. Adv. Water Resour. 2013, 51: 197-216.

Chang, F.F., Civan, F. Practical model for chemically Induced formation damage. J. Pet. Sci. Eng. 1997, 17(1-2): 123-137.

Civan, F. Incompressive cake filtration: Mechanism, parame-ters, and modeling. AIChE J. 1998, 44(11): 2379-2387.

Civan, F. Formation damage mechanisms and their phe-nomenological modeling–An overview. Paper SPE 107857 Presented at European Formation Damage Conference, Scheveningen, The Netherlands, 30 May-1 June, 2007.

Col ´on, C.F.J., Oelkers, E.H., Schott, J. Experimental investiga-tion of the effect of dissolution on sandstone permeability, porosity, and reactive surface area. Geochim. Cosmochim. Acta 2004, 68(4): 805-817.

Crandell, L.E., Peters, C.A., Um, W., et al. Changes in the pore network structure of Hanford sediment after reaction with caustic tank wastes. J. Contam. Hydrol. 2010, 131(14): 89-99.

Ding, S., Jiang, H., Liu, G., et al. Determining the levels and parameters of thief zone based on automatic history matching and fuzzy method. J. Pet. Sci. Eng. 2016, 138: 138-152.

Feng, Q., Han, X., Wang, S., et al. 3D network simulation study of the formation parameter variation sand reservoir during waterflooding process. Petroleum Geology and Recovery Efficiency 2013, 20(4): 79-82. (in Chinese)

Feng, Q., Han, X., Wang, S., et al. Network simulation of formation damage due to suspended particles in injection water. Journal of Southwest Petroleum University (Sci-ence & Technology Edition) 2014, 36(3): 179-184. (in Chinese)

Feng, Q., Li, S., Han, X.D., et al. Network simulation for for-mation impairment due to suspended particles in injected water. J. Pet. Sci. Eng. 2015, 133: 384-391.

Feng, Q., Wang, S., Gao, G., et al. A new approach to thief zone identification based on interference test. J. Pet. Sci. Eng. 2010, 75 (1-2): 13-18.

Feng, Q., Wang, S., Wang, S., et al. Identification of thief zones by dimensionless pressure index in waterfloods. Paper SPE 143926 Presented at SPE Enhanced Oil Recovery Conference, Kuala Lumpur, Malaysia, 19-21 July, 2011.

Fredd, C.N., Fogler, H.S. Influence of transport and reaction on wormhole formation in porous media. AIChE J. 1998, 44(9): 1933-1949.

Fredd, C.N., Fogler, H.S. Optimum conditions for wormhole formation in carbonate porous media: Influence of trans-port and reaction. SPE J. 1999, 4(3): 196-205.

Gielen, T., Hassanizadeh, S.M., Celia, M.A., et al. A pore-scale network approach to investigate dynamic effects in multiphase flow. Dev. Water Sci. 2004, 55: 83-94.

Jalel, O., Jean-Francois, V. A two-dimensional network model to simulate permeability decrease under hydrodynamic effect of particle release and capture. Transp. Porous Media 1999, 37(3): 303-325.

Joekar-Niasar, V., Hassanizadeh, S.M. Effect of fluids proper-ties on non-equilibrium capillarity effects: Dynamic pore-network modeling. Int. J. Multiph. Flow 2011, 37(2): 198-214.

Joekar-Niasar, V., Hassanizadeh, S.M., Dahle, H.K. Non-equilibrium effects in capillarity and inter facial area in two-phase flow: Dynamic pore-network modeling. J. Fluid Mech. 2010, 655(1): 38-71.

Khilar, K.C., Fogler, H.S. Water sensitivity of sandstones. SPE J. 1983, 23(1): 55-64.

Knudsen, H.A., Aker, E., Hansen, A. Bulk flow regimes and fractional flow in 2d porous media by numerical simulations. Transp. Porous Media 2002, 47(1): 99-121.

Li, D., Yang, J., Lu, D. Thief zone identification based on transient pressure analysis: A field case study. J. Pet. Explor. Dev. 2016, 6(1): 63-72.

Li, J., McDougall, S.R., Sorbie, K.S. Dynamic pore-scale network model (PNM) of water imbibition in porous media. Adv. Water Resour. 2017, 107: 191-211.

Liu, H., Li, G., Li, Y. Simulation of formation damage after long term water flooding. Paper SPE 158409 Presented at SPE Asia Pacific Oil and Gas Conference and Exhibition, Perth, Australia, 22-24 October, 2012.

Liu, Y., Bai, B., Wang, Y. Applied technologies and prospects of conformance control treatments in China. Oil Gas Sci. Technol. 2010, 65(6): 859-878.

Lux, J., Anguy, Y. A study of the behavior of implicit pressure explicit saturation (IMPES) schedules for two-phase flow in dynamic pore network models. Transp. Porous Media 2012, 93(1): 203-221.

Peng, S., Shi, Y., Han, T., et al. A quantitative description method for channeling path of reservoirs during high water cut period. Acta Petrolei Sinica 2007, 28(5): 79-84. (in Chinese)

Rege, S.D., Fogler, H.S. Network model for straining domi-nated particle entrapment in porous media. Chem. Eng. Sci. 1987, 42(7): 1553-1564.

Shokri, A.R., Babadagli, T. Field scale modeling of CHOPS and solvent/thermal based post CHOPS EOR applications considering non-equilibrium foamy oil behavior and real-istic representation of wormholes. J. Pet. Sci. Eng. 2016, 137: 144-156.

Szymczak, P., Ladd, A.J.C. Wormhole formation in dissolving fractures. J. Geophys. Res. 2009, 114(B6): B06203. Wang, H., Jiang, M., Zhang, J., et al. Simulation on variation of physical properties in high water cut reservoir. Acta Petrolei Sinica 2004, 25(6): 53-58. (in Chinese)

Wang, S., Feng, Q., Han, X. A hybrid analytical/numerical model for the characterization of preferential flow path with non-Darcy flow. PLOS ONE 2013, 8(12): e83536.

Wang, S.J., Civan, F. Modeling formation damage by asphal-tene deposition during primary oil recovery. J. Energy Resour. Technol. 2005, 127(4): 310-317.

Wang, S.L., Jiang, H.Q. Determine level of thief zone using fuzzy ISODATA clustering method. Transp. Porous Media 2011, 86(2): 513-520.

Wang, X.Z., Wang, J.Y., Wang, C.F., et al. Quantitative de-scription of characteristics of high-capacity channels in unconsolidated sandstone reservoirs using in situ produc-tion data. Pet. Sci. 2010, 7(1): 106-111.

Watson, M.G., Bondino, I., Hamon, G., et al. A pore-scale in-vestigation of low-salinity waterflooding in porous media: Uniformly wetted systems. Transp. Porous Media 2017, 118(2): 201-223