A critical review on fundamental mechanisms of spontaneous imbibition and the impact of boundary condition, fluid viscosity and wettability

Abstract

Spontaneous imbibition (SI) is one of the primary mechanisms of oil production from matrix system in fractured reservoirs. The main driving force for SI is capillary pressure. Researches relating to SI are moving fast. In the past few years, amount of literature on the development of SI with respect to many variables, such as mechanism of imbibition, scaling of imbibition data and wettability of matrix blocks. In this review, we first introduced the fundamental physics mechanism of SI through capillary tube models and micromodels. Then both conventional and more novel experimental methods of measuring oil production are discussed thoughtfully. This is followed by reviewing the oil production performance under various boundary conditions and the characteristic length in scaling equations that have been used to account for different cores shape and boundary conditions. The effect of fluid viscosity on the rate of oil production and final oil recovery as well as the development of viscosity term in the scaling equation are reported. The commonly used methods to quantitatively evaluate the wettability of cores and the SI under mix- and oil-wet conditions are introduced. And last but not least, the methods and mechanism of wettability alteration for enhanced oil recovery in mix- or oil-wet fractured reservoirs are presented.

Cited as: Meng, Q., Liu, H., Wang, J. A critical review on fundamental mechanisms of spontaneous imbibition and the impact of boundary condition, fluid viscosity and wettability. Advances in Geo-Energy Research, 2017, 1(1): 1-17, doi: 10.26804/ager.2017.01.01

References

Adibhatia, B., Sun, X., Mohanty, K. Numerical studies of oil production from initially oil-wet fracture blocks by surfactant brine imbibition. Paper SPE 97687 presented at the SPE International Improved Oil Recovery Conference in Asia Pacific, Kuala Lumpur, Malaysia, 5-6 December, 2005.

Adibhatla, B., Mohanty, K. Oil recovery from fractured carbonates by surfactant-aided gravity drainage: Laboratory experiments and mechanistic simulations. SPE Reserv. Eval. Eng. 2008, 11(1): 119-130.

Ahmadi, M.A., Galedarzadeh, M., Shadizadeh, S.R. Wettability alteration in carbonate rocks by implementing new derived natural surfactant: Enhanced oil recovery applications. Transp. Porous Media 2015, 106(3): 645-667.

Akin, S., Schembre, J.M., Bhat, S.K., et al. Spontaneous imbibition characteristics of diatomite. J. Pet. Sci. Eng. 2000, 25(3): 149-165.

Amott, E. Observations relating to the wettability of porous rock. Trans. AIME 1959, 216: 156-162.

Anderson, W. Wettability literature survey-part 2: Wettability measurement. J. Pet. Technol. 1986, 38(11): 1246-1261.

Austad, T., Matre, B., Milter, J., et al. Chemical flooding of oil reservoirs 8. Spontaneous oil expulsion from oil-and water-wet low permeable chalk material by imbibition of aqueous surfactant solutions. Colloids Surf. A 1998, 137(1-3): 117-129.

Austad, T., Milter, J. Spontaneous imbibition of water into low permeable chalk at different wettabilities using surfactants. Paper SPE 37236 Presented at the International Symposium on Oilfield Chemistry, Houston, Texas, 18-21 February, 1997.

Babadagli, T. Dynamics of capillary imbibition when surfactant, polymer, and hot water are used as aqueous phase for oil recovery. J. Colloid Interface Sci. 2002, 246(1): 203-213.

Baldwin, B.A., Spinler, E.A. In situ saturation development during spontaneous imbibition. J. Pet. Sci. Eng. 2002, 35(1): 23-32.

Behbahani, H.S., Di Donato, G., Blunt, M.J. Simulation of counter-current imbibition in water-wet fractured reservoirs. J. Pet. Sci. Eng. 2006, 50(1): 21-39.

Benner, F.C., Bartel, F.E. The effect of polar impurities upon capillary and surface phenomena in petroleum production. Paper API41341 Presented at the Drilling and Production Practice, New York, 1 January, 1941.

Bourbiaux, B.J., Kalaydjian, F.J. Experimental study of cocurrent and countercurrent flows in natural porous media. SPE Reserv. Eval. Eng. 1990, 5(1): 361-368.

Buckley, J.S., Liu, Y., Monsterleet, S. Mechanisms of wetting alteration by crude oils. SPE J. 1998, 3(1): 54-61.

Cai, J.C., Perfect, E., Cheng, C.L., et al. Generalized modeling of spontaneous imbibition based on Hagen-Poiseuille flow in tortuous capillaries with variably shaped apertures. Langmuir 2014, 30(18): 5142-5151.

Cai, J.C., Yu, B.M. A discussion of the effect of tortuosity on the capillary imbibition in porous media. Transp. Porous Media 2011, 89(2): 251-263.

Cai, J.C., Yu, B.M. Advances in studies of spontaneous imbibition in porous media. Advances in Mechanics 2012, 42(6): 735-754. (in Chinese)

Cai, J.C., Yu, B.M., Zou, M.Q., et al. Fractal characterization of spontaneous co-current imbibition in porous media. Energy Fuels 2010, 24(3): 1860-1867.

Chatzls, I., Kuntamukkula, M.S., Morrow, N.R. Effect of capillary number on the microstructure of residual oil in strongly water-wet sandstones. SPE Reserv. Eng. 1988, 3(3): 902-912.

Chen, P., Mohanty, K.K. Surfactant-mediated spontaneous imbibition in carbonate rocks at harsh reservoir conditions. SPE J. 2013, 18(1): 124-133.

Chen, P., Mohanty, K.K. Surfactant-enhanced oil recovery from fractured oil-wet carbonates: Effects of low IFT and wettability alteration. Paper SPE 173797 Presented at the SPE International Symposium on Oilfield Chemistry, The Woodlands, Texas, USA, 13-15 April, 2015.

Chilingar, G.V., Yen, T.F. Some notes on wettability and relative permeabilities of carbonate reservoir rocks II. Energy Sources 1983, 7(1): 67-75.

Clementz, D.M. Alteration of rock properties by adsorption of petroleum heavy ends: Implications for enhanced oil recovery. Paper SPE 10683 Presented at the Enhanced Oil Recovery Symposium, Tulsa, Oklahoma, 4-7 April, 1982.

Donaldson, E.C. Wettability literature survey-part 2: Wettability measurement. J. Pet. Technol. 1986, 38(11): 1246-1262.

Donaldson, E.C., Kendall, R.F., Pavelka, E.A., et al. Equipment and procedures for fluid flow and wettability tests of geological materials. Paper Presented at Bartlesville Energy Technology Center, 1 May, 1980.

Donaldson, E.C., Thomas, R.D., Lorenz, P.B. Wettability determination and its effect on recovery efficiency. SPE J. 1969, 9(1): 13-20.

Dong, M., Dullien, F.A.L., Dai, L., et al. Immiscible displacement in the interacting capillary bundle model part I. development of interacting capillary bundle model. Transp. Porous Media 2005, 59(1): 1-18.

Dong, M., Dullien, F.A.L., Dai, L., et al. Immiscible displacement in the interacting capillary bundle model part II, applications of model and comparison of interacting and non-interacting capillary bundle models. Transp. Porous Media 2006, 63(2): 289-304.

Dong, M., Dullien, F.A.L., Zhou, J. Characterization of waterflood saturation profile histories by the complete capillary number. Transp. Porous Media 1998, 31(2): 213-237.

Dubey, S.T., Waxman, M.H. Asphaltene adsorption and desorption from mineral surfaces. SPE Reserv. Eng. 1991, 6(3): 389-395.

Eriksson, J., Tiberg, F., Zhmud, B. Wetting effects due to surfactant carryover through the three-phase contact line. Langmuir 2001, 17(23): 7274-7279.

Fernø, M., Haugen, ˚A., Wickramathilaka, S., et al. Magnetic resonance imaging of the development of fronts during spontaneous imbibition. J. Pet. Sci. Eng. 2013, 101: 1-11.

Fernø, M.A., Torsvik, M., Haugland, S., et al. Dynamic laboratory wettability alteration. Energy Fuels 2010, 24(7): 3950-3958.

Fischer, H. Oil recovery by spontaneous imbibition for a wide range of viscosity ratios. Laramie, The University of Wyoming, 2006.

Fischer, H., Morrow, N.R. Spontaneous imbibition with matched liquid viscosities. Paper SPE 96812 Presented at SPE Annual Technical Conference and Exhibition, Dallas, Texas, 9-12 October, 2005.

Fischer, H.M., Wo, S., Morrow, N.R. Modeling the effect of viscosity ratio on spontaneous imbibition. SPE Reserv. Eval. Eng. 2008, 11(3): 577-589.

Freer, E.M., Svitova, T., Radke, C.J. The role of interfacial rheology in reservoir mixed wettability. J. Pet. Sci. Eng. 2003, 39(1-2): 137-158.

Graue, A., Viksund, B.G., Baldwin, B.A. Reproducible wettability alteration of low-permeable outcrop chalk. SPE Reserv. Eval. Eng. 1999, 2(2): 134-140.

Gupta, R., Mohanty, K.K. Temperature effects on surfactant-aided imbibition into fractured carbonates. SPE J. 2010, 15(3): 588-597.

Hamidpour, E., Mirzaei-Paiaman, A., Masihi, M., et al. Experimental study of some important factors on nonwetting phase recovery by cocurrent spontaneous imbibition. J. Nat. Gas Sci. Eng. 2015, 27: 1213-1228.

Hammond, P.S., Unsal, E. Spontaneous and forced imbibition of aqueous wettability altering surfactant solution into an initially oil-wet capillary. Langmuir 2009, 25(21): 12591-12603.

Hammond, P.S., Unsal, E. Forced and spontaneous imbibition of surfactant solution into an oil-wet capillary: The effects of surfactant diffusion ahead of the advancing Meniscus. Langmuir 2010, 26(9): 6206-6221.

Hammond, P.S., Unsal, E. Spontaneous imbibition of surfactant solution into an oil-wet capillary: Wettability restoration by surfactant contaminant complexation. Langmuir 2011, 27(8): 4412-4429.

Hatiboglu, C.U., Babadagli, T. Pore-scale studies of spontaneous imbibition into oil-saturated porous media. Phys. Rev. E 2008, 77(6): 066311.

Hatiboglu, C.U., Babadagli, T. Experimental and visual analysis of co-and counter-current spontaneous imbibition for different viscosity ratios, interfacial tensions, and wettabilities. J. Pet. Sci. Eng. 2010, 70(3-4): 214-228.

Haugen, ˚A., Fernø, M.A., Mason, G., et al. Capillary pressure and relative permeability estimated from a single spontaneous imbibition test. J. Pet. Sci. Eng. 2014, 115: 66-77.

Haugen, ˚A., Fernø, M.A., Mason, G., et al. The effect of viscosity on relative permeabilities derived from spontaneous imbibition tests. Transp. Porous Media 2015, 106(2): 383-404.

Haugland, H.K. Spontaneous imbibition in sand viscosity effects on oil recovery and flow using polymer and glycerol. Bergen, University of Bergen, 2016.

Hgnesen, E.J., Olsen, M., Austad, T. Capillary and gravity dominated flow regimes in displacement of oil from an oil-wet chalk using cationic surfactant. Energy Fuels 2006, 20(3): 1118-1122.

Hirasaki, G., Zhang, D.L. Surface chemistry of oil recovery from fractured, oil-wet, carbonate formations. SPE J. 2004, 9(2): 151-162.

Hu, Q., Ewing, R.P., Dultz, S. Low pore connectivity in natural rock. J. Contam. Hydrol. 2012, 133: 76-83.

Jadhunandan, P.P., Morrow, N.R. Effect of wettability on waterflood recovery for crude-oil/brine/rock systems. SPE Reserv. Eng. 1995, 10(1): 40-46.

Karpyn, Z.T., Halleck, P.M., Grader, A.S. An experimental study of spontaneous imbibition in fractured sandstone with contrasting sedimentary layers. J. Pet. Sci. Eng. 2009, 67(1-2): 48-56.

Kazemi, H., Gilman, J.R., Elsharkawy, A.M. Analytical and numerical solution of oil recovery from fractured reservoirs with empirical transfer functions. SPE Reserv. Eng. 1992, 2(7): 219-226.

Kovscek, A.R., Radke C.J. Pressure-driven capillary snap-off of gas bubbles at low wetting-liquid content. Colloids Surf. A 2003, 212(2): 99-108.

Kumar, K., Dao, E.K., Mohanty, K.K. Atomic force microscopy study of wettability alteration by surfactants. SPE J. 2008, 13(2): 137-145.

Kumar, N., Varanasi, K., Tilton, R.D., et al. Surfactant self-assembly ahead of the contact line on a hydrophobic surface and its implications for wetting. Langmuir 2003, 19(13): 5366-5373.

Li, K., Horne, R.N. Characterization of spontaneous water imbibition into gas-saturated rocks. SPE J. 2001, 6(4): 375-384.

Li, K., Horne, R.N. Generalized scaling approach for spontaneous imbibition: An analytical model. SPE Reserv. Eval. Eng. 2006, 9(3): 251-258.

Li, Y. Analytical solutions for linear counter-current spontaneous imbibition in the frontal flow period. Transp. Porous Media 2011, 86(3): 827-850.

Li, Y., Mason, G., Morrow, N.R., et al. Capillary pressure at the imbibition front during water-oil counter-current spontaneous imbibition. Transp. Porous Media 2009, 77(3): 475-487.

Li, Y., Mason, G., Morrow, N.R., et al. Capillary pressure at a saturation front during restricted counter-current spontaneous imbibition with liquid displacing air. Transp. Porous Media 2011, 87(1): 275-289.

Li, Y., Ruth, D., Mason, G., et al. Pressures acting in counter-current spontaneous imbibition. J. Pet. Sci. Eng. 2006, 52(1-4): 87-99.

Loahardjo, N., Xie, X., Morrow, N.R. Oil recovery by sequential waterflooding of mixed-wet sandstone and limestone. Energy Fuels 2010, 24(9): 5073-5080.

Ma, S., Morrow, N.R., Zhang, X. Generalized scaling of spontaneous imbibition data for strongly water-wet systems. J. Pet. Sci. Eng. 1997, 18(3-4): 165-178.

Mason, G., Fernø, M.A., Haugen, ˚A., et al. Spontaneous counter-current imbibition outwards from a hemi-spherical depression. J. Pet. Sci. Eng. 2012, 90: 131-138.

Mason, G., Fischer, H., Morrow, N.R., et al. Spontaneous counter-current imbibition into core samples with all faces open. Transp. Porous Media 2009, 78(2): 199-216.

Mason, G., Fischer, H., Morrow, N.R., et al. Oil production by spontaneous imbibition from sandstone and chalk cylindrical cores with two ends open. Energy Fuels 2010a, 24(2): 1164-1169.

Mason, G., Fischer, H., Morrow, N.R., et al. Correlation for the effect of fluid viscosities on counter-current spontaneous imbibition. J. Pet. Sci. Eng. 2010b, 72(1-2): 195-205.

Mason, G., Morrow, N.R. Developments in spontaneous imbibition and possibilities for future work. J. Pet. Sci. Eng. 2013, 110: 268-293.

Mattax, C.C., Kyte, J.R. Imbibition oil recovery from fractured, water-drive reservoir. SPE J. 1962, 2(2): 177-184.

Meng, Q., Liu, H., Wang, J. Entrapment of the non-wetting phase during co-current spontaneous imbibition. Energy Fuels 2015, 29(2): 686-694.

Meng, Q., Liu, H., Wang, J. Effect of viscosity on oil production by cocurrent and countercurrent imbibition from cores with two ends open. SPE Reserv. Eval. Eng. 2016a. (Preprint)

Meng, Q., Liu, H., Wang, J., et al. Asymmetry characteristics of oil production by spontaneous imbibition from cores with two ends open. Transp. Porous Media 2016b, 113(3): 735-751.

Meng, Q., Liu, H., Wang, J., et al. Effect of wetting-phase viscosity on cocurrent spontaneous imbibition. Energy Fuels 2016c, 30(2): 835-843.

Meng, Q., Liu, H., Wang, J., et al. Effect of fluid viscosity on correlation of oil recovery by linear counter-current spontaneous imbibition. J. Pet. Sci. Eng. 2017, 151: 341-347.

Meza, O.E., Peralta, V., Nu ˜nez, E. Influence of stress field in the productivity of naturally fractured reservoirs in metamorphic basement: A case study of the San Pedro Field, Amotape Group. Paper SPE 138946 Presented at the SPE Latin American and Caribbean Petroleum Engineering Conference, Lima, Peru, 1-3 December, 2010.

Mirzaei-Paiaman, A., Masihi, M. Scaling equations for oil/gas recovery from fractured porous media by counter-current spontaneous imbibition: From development to application. Energy Fuels 2013, 27(8): 4662-4676.

Mirzaei-Paiaman, A., Masihi, M. Scaling of recovery by cocurrent spontaneous imbibition in fractured petroleum reservoirs. Energy Technol. 2014, 2(2): 166-175.

Mirzaei-Paiaman, A., Masihi, M., Standnes, D.C. An analytic solution for the frontal flow period in 1-D counter-current spontaneous imbibition into fractured porous media including gravity and wettability effects. Transp. Porous Media 2011, 89(1): 49-62.

Morrow, N.R. Wettability and its effect on oil recovery. J. Pet. Technol. 1990, 12(42): 1476-1484.

Morrow, N.R., Chatzis, I., Taber, J.J. Entrapment and mobilization of residual oil in bead packs. SPE Reserv. Eng. 1988, 3(3): 927-934.

Morrow, N.R., Cram, P.J., McCaffery, F.G. Displacement studies in dolomite with wettability control by octanoic acid. SPE J. 1973, 14(3): 221-231.

Morrow, N.R., Mason, G. Recovery of oil by spontaneous imbibition. Curr. Opin. Colloid Interface Sci. 2001, 6(4): 321-337.

Nguyen, V.H., Sheppard, A.P., Knackstedt, M.A., et al. The effect of displacement rate on imbibition relative permeability and residual saturation. J. Pet. Sci. Eng. 2006, 52(1-4): 54-70.

Oak, M.J. Three-phase relative permeability of water-wet berea. Paper SPE 20183 Presented at the SPE/DOE Enhanced Oil Recovery Symposium, Tulsa, Oklahoma, USA, 22-25 April, 1990.

Pooladi-Darvish, M., Firoozabadi, A. Cocurrent and countercurrent imbibition in a water-wet matrix block. SPE J. 2000, 5(1): 3-11.

Qiao, C., Li, L., Johns, R.T., et al. A mechanistic model for wettability alteration by chemically tuned waterflooding in carbonate reservoirs. SPE J. 2015, 20(4): 767-783.

Rangel-German, E.R., Kovscek, A.R. A micromodel investigation of two-phase matrix-fracture transfer mechanisms. Water Resour. Res. 2006a, 42(3): W03401.

Rangel-German, E.R., Kovscek, A.R. Time-dependent matrix-fracture shape factors for partially and completely immersed fractures. J. Pet. Sci. Eng. 2006b, 54(3-4): 149-163.

Reis, J.C., Cil, M. A model for oil expulsion by counter-current water imbibition in rocks: One-dimensional geometry. J. Pet. Sci. Eng. 1993, 10(2): 97-107.

Rostami Ravari, R., Strand, S., Austad, T. Combined surfactant-enhanced gravity drainage (SEGD) of oil and the wettability alteration in carbonates: The effect of rock permeability and interfacial tension (IFT). Energy Fuels 2011, 25(5): 2083-2088.

Ruth, D., Bartley, J. Capillary tube models with interaction between the tubes. Transp. Porous Media 2011, 86(2): 479-482.

Ruth, D., Bartley, J. A perfect-cross-flow model for two phase flow in porous media. Paper Presented at the Proceedings of the International Society of Core Analysts Annual Meeting, Monterey, CA, 22-25 September, 2002.

Ruth, D.W., Arthur, J.K. A revised analytic solution to the linear displacement problem including capillary pressure effects. Transp. Porous Media 2011, 86(3): 881-894.

Ruth, D.W., Li, Y., Mason, G., et al. An approximate analytical solution for counter-current spontaneous imbibition. Transp. Porous Media 2007, 66(3): 373-390.

Salathiel, R.A. Oil recovery by surface film drainage in mixed-wettability rocks. J. Pet. Technol. 1973, 25(10): 1216-1224.

Salehi, M., Johnson, S.J., Liang, J. Mechanistic study of wettability alteration using surfactants with applications in naturally fractured reservoirs. Langmuir 2008, 24(24): 14099-14107.

Somasundaran, P., Zhang, L. Adsorption of surfactants on minerals for wettability control in improved oil recovery processes. J. Pet. Sci. Eng. 2006, 52(1-4): 198-212.

Spinler, E.A., Zornes, D.R., Tobola, D.P., et al. Enhancement of oil recovery using a low concentration of surfactant to improve spontaneous and forced imbibition in chalk. Paper SPE 59290 Presented at the SPE/DOE Improved Oil Recovery Symposium, Tulsa, Oklahoma, 3-5 April, 2000.

Standnes, D. Wettability alteration in chalk 1. Preparation of core material and oil properties. J. Pet. Sci. Eng. 2000, 28(3): 111-121.

Standnes, D.C. Experimental study of the impact of boundary conditions on oil recovery by co-current and counter-current spontaneous imbibition. Energy Fuels 2004, 18(1): 271-282.

Standnes, D.C. Calculation of viscosity scaling groups for spontaneous imbibition of water using average diffusivity coefficients. Energy Fuels 2009, 23(4): 2149-2156.

Standnes, D.C., Austad, T. Wettability alteration in chalk 2. Mechanism for wettability alteration from oil-wet to water-wet using surfactants. J. Pet. Sci. Eng. 2000, 28(3): 123-143.

Unsal, E., Mason, G., Morrow, N.R., et al. Co-current and counter-current imbibition in independent tubes of non-axisymmetric geometry. J. Colloid Interface Sci. 2007a, 306(1): 105-117.

Unsal, E., Mason, G., Morrow, N.R., et al. Bubble snap-off and capillary-back pressure during counter-current spontaneous imbibition into model pores. Langmuir 2009, 25(6): 3387-3395.

Unsal, E., Mason, G., Ruth, D.W., et al. Co-and counter-current spontaneous imbibition into groups of capillary tubes with lateral connections permitting cross-flow. J. Colloid Interface Sci. 2007b, 315(1): 200-209.

Wang, J., Dullien, F.A.L., Dong, M. Fluid transfer between tubes in interacting capillary bundle models. Transp. Porous Media 2008, 71(1): 115-131.

Washburn, E.W. The dynamics of capillary flow. Phys. Rev. 1921, 17(3): 273-283.

Wickramathilaka, S., Howard, J.J., Stevens, J.C., et al. Magnetic resonance imaging of oil recovery during spontaneous imbibition from cores with two-ends open boundary condition. Paper Presented at the International Symposium of the Society of Core Analysts held in Austin, Texas, USA, 18-21 September, 2011.

Xie, X., Morrow, N.R., Buckley, J.S. Contact angle hysteresis and the stability of wetting changes induced by adsorption from crude oil. J. Pet. Sci. Eng. 2002, 33(1): 147-159.

Yildiz, H.O., Gokmen, M., Cesur, Y. Effect of shape factor, characteristic length, and boundary conditions on spontaneous imbibition. J. Pet. Sci. Eng. 2006, 53(3-4): 158-170.

Yu, L., Buckley, J.S. Evolution of wetting alteration by adsorption from crude oil. SPE Reserv. Eng. 1997, 11(4): 280-285.

Zhang, H., Nikolov, A., Wasan, D. Enhanced oil recovery (EOR) using nanoparticle dispersions: Underlying mechanism and imbibition experiments. Energy Fuels 2014, 28(5): 3002-3009.

Zhang, P., Tweheyo, M.T., Austad, T. Wettability alteration and improved oil recovery by spontaneous imbibition of seawater into chalk: Impact of the potential determining ions Ca2+ , Mg2+ , and SO2+ 4 . Colloids Surf. A 2007, 301(1-3): 199-208.

Zhang, X., Morrow, N.R., Ma, S. Experimental verification of a modified scaling group for spontaneous imbibition. SPE Reserv. Eng. 1996, 11(4): 280-285.

Zhou, D., Jia, L., Kamath, J., et al. Scaling of counter-current imbibition processes in low-permeability porous media. J. Pet. Sci. Eng. 2002, 33(1): 61-74.

Zhou, X., Morrow, N.R., Ma, S. Interrelationship of wettability, initial water saturation, aging time, and oil recovery by spontaneous imbibition and waterflooding. SPE J. 2000, 5(2): 199-207.