Numerical simulation of power-law acid flow in rough fractures of carbonate rocks

Authors

  • Xu Liu College of Energy, Chengdu University of Technology, Chengdu 610059, P. R. China; State Key Laboratory of Oil and Gas Reservoir Geology and Exploitation, Chengdu University of Technology, Chengdu 610059, P. R. China
  • Qin Li* College of Energy, Chengdu University of Technology, Chengdu 610059, P. R. China; State Key Laboratory of Oil and Gas Reservoir Geology and Exploitation, Chengdu University of Technology, Chengdu 610059, P. R. China (Email: cdutliqin@163.com)
  • WenLing Chen College of Energy, Chengdu University of Technology, Chengdu 610059, P. R. China; State Key Laboratory of Oil and Gas Reservoir Geology and Exploitation, Chengdu University of Technology, Chengdu 610059, P. R. China
  • Na Li* College of Energy, Chengdu University of Technology, Chengdu 610059, P. R. China; State Key Laboratory of Oil and Gas Reservoir Geology and Exploitation, Chengdu University of Technology, Chengdu 610059, P. R. China (Email: lina@mail.ustc.edu.cn)
  • Yan Huang Zhundong Drilling Company of CNPC Xibu Drilling Engineering Co., Ltd., Urumqi 834000, P. R. China
  • Huazhou Li School of Mining and Petroleum Engineering, Faculty of Engineering, University of Alberta, Edmonton T6G 1H9, Canada

Abstract

Acid fracturing is the most widely applied technology for stimulating carbonate reservoirs. Meanwhile, the effectiveness of this method largely depends on factors such as acid penetration distance, fracture morphology and conductivity, all of which are closely governed by acid flow behavior. A wealth of numerical simulations have been conducted to characterize acid flow during fracturing, whereas the coupled effects of acid rheological properties and fracture surface roughness on the acid flow behavior remain underexplored. In this work, a three-dimensional numerical model of acid etching fracture was developed by coupling an acid-rock reaction model with computational fluid dynamics methods, which comprehensively incorporates the rheological property of acid and fracture surface roughness. Validation against experimental data showed a deviation of 11.15% in dissolved mass, with errors within 10.00% for most roughness parameters, confirming the numerical model’s accuracy. Furthermore, the numerical model was employed to investigate the quantitative effect of the rheological index on acid transport and the spatiotemporal evolution of acid flow and dissolution. The results revealed significant interdependencies among flow velocity, shear rate, acid-rock reaction rate, and fracture width, all of which evolve dynamically over time and space. Moreover, it was found that the non-uniform distribution of flow velocity, shear rate, acid-rock reaction rate is caused by fracture surface roughness, and the degree of non-uniformity is enhanced as the shear-thinning capacity of the acid increases. This work provides a robust numerical framework for the simulation of the transport and reaction of acids with power-law characteristics in three-dimensional rough fractures, thus offers valuable theoretical insights for guiding the optimization of acid fracturing parameters and enhancing reservoir stimulation efficiency.

Document Type: Original article

Cited as: Liu, X., Li, Q., Chen, W., Li, N., Huang, Y., Li, H. Numerical simulation of power-law acid flow in rough fractures of carbonate rocks. Advances in Geo-Energy Research, 2025, 17(3): 226-240. https://doi.org/10.46690/ager.2025.09.05

Keywords:

Acid fracturing, acid-rock reaction, rheological property, rough fracture, numerical simulation

References

Abdelgawad, K. Z., Mahmoud, M., Hussein, I. Stimulation of high temperature carbonate gas reservoirs using seawater and chelating agents: Reaction kinetics. Journal of Natural Gas Science and Engineering, 2018,55:595-605.

Afsar, H., Samadi, F., Esmaeilzadeh, F., et al. 3-d numerical simulation of sandstone matrix acidizing by non-newtonian fluid. Journal of Petroleum Science and Engineering, 2022, 208:109666.

Alhubail, M. M., Misra, A., Barati, R. Anovel acid transport model with robust finite element discretization. Paper SPE188030 Presented at SPE Kingdom of Saudi Arabia Annual Technical Symposium and Exhibition, Dammam, Saudi Arabia, 24-27 April, 2017.

Aljawad, M. S., Schwalbert, M. P., Zhu, D., et al. Improving acid fracture design in dolomite formations utilizing a fully integrated acid fracture model. Journal of Petroleum Science and Engineering, 2020, 184:106481.

Al-Shargabi, M., Davoodi, S., Wood, D. A., et al. Acritical review of self-divertin gacid treatments applied to carbonate oil and gas reservoirs. Petroleum Science, 2023, 20(2): 922-950.

Barboza, R. P., Schwalbert, M. P., Favero, J. L., et al. Modeling and simulation of the carbonate reactive-dissolution process by viscoelastic-surfactant-based acid. Journal of Petroleum Science and Engineering, 2022, 215: 110595.

Bird, R. B., Stewart, W. E., Lightfoot, E. N. Transport phenomena, revised 2nd edition. Hoboken, USA, John Wiley & Sons, 2006.

Chen, Y., Mao, H., Nie, W., et al. Investigation of nonlinear f low behavior along a rough-walled limestone fracture with acid dissolution. Rock Mechanics and Rock Engineering, 2024, 57(5): 3355-3369.

Deng, Y., Yang, Y., Yang, T. Three systems of the oil and gas formation in the world. Petroleum Research, 2025, 10(1): 1-27.

Dong, C., Zhu, D., Hill, A. D. Modeling of the acidizing process in naturally fractured carbonates. SPE Journal, 2002, 7(4): 400-408.

Guo, J., Gou, B., Qin, N., et al. An innovative concept on deep carbonate reservoir stimulation: Three-dimensional acid fracturing technology. Natural Gas Industry B, 2020, 7(5): 484-497.

Gou, B., Qin, N., Wang, C., et al. Acidizing model to couple the closure stress and acid-rock reactive transport in naturally fractured carbonate reservoir. Paper ARMA 20211221 Presented at 55th U.S. Rock Mechanics/Geomechanics Symposium, Virtual, 18-25 June, 2021.

HaghaniGalougahi, M. Pore-scale simulation of calcite matrix acidizing with hydrochloric acid. SPE Journal, 2021, 26(2): 653-666.

Huang, Z., Xing, H., Zhou, X., et al. Numerical study of vug effects on acid-rock reactive flow in carbonate reservoirs. Advances in Geo-Energy Research, 2020, 4(4): 448-459.

Ivanishin, I., Kotb, A., Nasr-El-Din, H. A. Turbulence leads to overestimation of the acid-diffusion coefficient at typical experimental conditions using the rotating disk apparatus. Journal of Petroleum Science and Engineering, 2021, 205: 108805.

Ignatenko, E. V., Bryanskaya, Y. V. Velocity distribution in channels of various geometry and roughness. Power Technology and Engineering, 2023, 57(3): 412-414.

Jiang, Q., Yang, X., Gong, F. Development and evaluation of high temperature resistant cross-linked acid fracturing fluid system. Chemical Industry and Engineering, 2022, 39(1): 51-57.

Kadafur, I. B. Aljawad, M. S., Mahmoud, M. Review of acid diffusion measurement methods in porous media. Energy & Fuels, 2020, 34(10): 11916-11941.

Karayel, G. K., Javani, N., Dincer, I. Effective use of geother mal energy for hydrogen production: A comprehensive application. Energy, 2022, 249: 123597.

Kong, X., Liu, B., Wan, X., et al. Experimental evaluation and optimization of improved conductivity of gelling acid etched fractures in deep, low-permeability reservoirs. Fuel, 2023, 348: 128468.

Kotb, A., Ezzat, A. A., Ali, M., et al. A calibrated computational fluid dynamics model for simulating the rotating disk apparatus. SPE Journal, 2021, 26(6): 4022-4036.

Kumar, U., Panda, D., Biswas, K. G. Augmented mass transfer in liquid-liquid flow through microchannels of different geometries. Chemical Engineering and Processing Process Intensification, 2019, 137: 72-79.

Lavrov, A. Redirection and channelization of power-law fluid f low in a rough-walled fracture. Chemical Engineering Science, 2013, 99: 81-88.

Li, H., Shi, Y. Synthesis and performance of temperature and acid-resistant ternary-copolymer thickener. Materials Chemistry and Physics, 2022, 292: 126866.

Li, Q., Yi, X., Lu, Y., et al. The law of the hydrogen ion diffusion coefficient in acid rock reaction. Journal of Petroleum Science and Engineering, 2016, 146: 694-701.

Ling, X., Yu, H., Qing, Y., et al. Acid fracturing: A perspective. International Journal of Earth Sciences Knowledge and Applications, 2024, 6(3): 397-400.

Liu, P., Hu, H., Chen, X., et al. The influencing parameters and improve methods of acid-etched fracture conductivity: A review. Geoenergy Science and Engineering, 2024, 238: 212844.

Liu, P., Kong, X., Feng, G., et al. Three-dimensional simulation of wormhole propagation in fractured-vuggy carbonate rocks during acidization. Advances Geo-Energy Research, 2023b, 7(3): 199-210.

Liu, X., Li, Q., Li, N., et al. Numerical simulation of acid f low in rough fractures. SPE Journal, 2025a, 30(5): 3009 3028.

Liu, Z., Qi, N., Jiang, P., et al. Developments of acid fracturing technology for enhanced geothermal systems: A review. Applied Energy, 2025b, 388: 125650.

Liu, J., Zhao, J., Qin, S., et al. Research and application of acid fracturing stimulation mechanism in ultra-deep subsalt dolomite reservoir in tarim basin. Journal of Petroleum Exploration and Production Technology, 2023a, 13(3): 877-889.

Lo, K. K., Dean, R. H. Modeling of acid fracturing. SPE Production Engineering, 1989, 4(2): 194-200.

Maheshwari, P., Maxey, J., Balakotaiah, V. Reactive dissolution modeling and experimental comparison of wormhole formation in carbonates with gelled and emulsified acids. SPE Production & Operations, 2016, 31(2): 103-119.

Mehrabi, M., Fatemi Aghda, S. M., Sarkheil, H., et al. A systematic review to identify carbonate rock exploration paradigms and examine current and future research directions: A case study at one of the southwest oil fields of iran. Journal of Petroleum Exploration and Production Technology, 2025, 15(2): 34.

Nasr-El-Din, H. A., Al-Mohammad, A. M., Al-Aamri, A. D., et al. Quantitative analysis of reaction-rate retardation in surfactant-based acids. SPE Production & Operations, 2009, 24(1): 107-116.

Peng, J., Feng, R., Xue, M., et al. Research progress and engineering applications of viscous fluid mechanics. Applied Sciences, 2025, 15(1): 357.

Romero, J., Gu, H., Gulrajani, S. N. 3D transport in acid fracturing treatments: Theoretical development and consequences for hydrocarbon production. SPE Production & Facilities, 2001, 16(2): 122-130.

Song, C., Lee, J. Reaction kinetics of an emulsified acid using a mixed emulsifier and carbonate rocks. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 2023, 679: 132544.

Subedi, J., Rajendran, S., Manglik, R. M. Laminar forced convection in viscous shear-thinning liquid flows inside circular pipes: Case for a modified power-law rheology. Journal of Heat Transfer, 2020, 142(12): 121802.

Sui, Y., Cao, G., Tian, Y., et al. Application, progress, and trend of thickened acid fracturing in carbonate rock reservoir development. Processes, 2024, 12(10): 2269.

Ugursal, A., Zhu, D., Hill, A. D. Development of acid fracturing model for naturally fractured reservoirs. SPE Production & Operations, 2019, 34(4): 735-748.

van Domselaar, H. R., Schols, R. S., Visser, W. An analysis of the acidizing process in acid fracturing. Society of Petroleum Engineers Journal, 1973, 13(4): 239-250.

Wang, P., Gou, Q., Zhang, B., et al. Application of 3d rough discrete fracture networks to fluid flow processes in fractured rock masses. Geomechanics and Geophysics for Geo-Energy and Geo-Resources, 2025a, 11(1): 23.

Wang, S., Zhang, D., Guo, J., et al. Experiment and analysis of the reaction kinetics of temperature control viscosity acids with limestone. Journal of Petroleum Science and Engineering, 2018, 165: 305-312.

Wang, S., Zhang, W., Gao, J., et al. Characteristics of shear thickening fluid and its application in engineering: A state-of-the-art review. The International Journal of Ad vanced Manufacturing Technology, 2024, 133(5): 1973-2000.

Wang, X., Song, Y., Wu, P., et al. Rheological properties of hydroxypropyl guar gum fracturing fluids: Effects of cross-linking agents. Carbohydate Polymers, 2025b, 366: 123837.

Wang, Y., Fan, Y., Wang, T., et al. A new compound staged gelling acid fracturing method for ultra-deep horizontal wells. Gels, 2022, 8(7): 449.

Williams, B. B., Nierode, D. E. Design of acid fracturing treatments. Journal of Petroleum Technology, 1972, 24(7): 849-859.

Xu, D., Lei, H., Xiao, H., et al. Observation via particle image velocity (PIV) technology of seepage features in replicas of rock fractures. Rock Mechanics and Rock Engineering, 2024, 57(9): 6527-6541.

Xu, S., Zhou, S., Zhou, J., et al. Multiscale pore structure evolution of longmaxi shale induced by acid treatment. SPE Journal, 2023, 28(2): 831-844.

Yu, Y., Cui, J., Zhang, R., et al. Gelling acid thickener for oil and gas production: Preparation, properties and applications. Oilfield Chemistry, 2021, 38(3): 553-559. (in Chinese)

Zeng, M., Zhou, H. Investigation of acid-etching evolution in natural fractures of carbonate reservoirs under high closure stress. SPE Journal, 2025, 30(1): 98-110.

Zhang, Y., Kuang, J., Zhang, H., et al. Experimental study on the acid fracturing fracture propagation law of a fractured carbonate reservoir in the majiagou formation. Processes, 2025, 13(3): 695.

Zhao, F., Jiao, X., Xia, X., et al. Evolution of rock pore structure and physical properties due to acidification: Recent advances and future perspectives. Advances in Geo-Energy Research, 2024, 14(3): 238-240.

Zhao, M., Li, Y., Xu, Z., et al. Dynamic cross-linking mechanism of acid gel fracturing fluid. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 2020, 607: 125471.

Zhu, D., Wang, Y., Cui, M., et al. Acid system and stimulation efficiency of multistage acid fracturing in porous carbonate reservoirs. Processes, 2022, 10(9): 1883.

Zhu, T., Zhang, Z., Liu, Z., et al. Simulation of hydraulic mechanical-chemical coupled acid fracturing of rock with lattice bonds. Heliyon, 2024, 10(4): e26517.

Downloads

Download data is not yet available.

Downloads

Published

2025-08-31

Issue

Vol. 17 No. 3 (2025): September (In Progress)

Section

Articles

License

Copyright (c) 2025 Author(s)

Creative Commons License

This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.