Assessment of CO₂-energized fracturing methods: Their impacts on fracturing fluid flowback and CO₂ geological storage in deep tight gas reservoirs
Abstract
CO₂-energized fracturing holds great potential for enhancing fracturing fluid flowback and enabling effective CO₂ sequestration, while the effect of the choice of CO₂ energization strategy on these processes is not yet fully understood. This study experimentally investigated three representative CO₂ energization methods: Pre-fracturing injection, foam injection, and co-injection. Nuclear magnetic resonance techniques were applied to systematically analyze the influence of various CO₂ injection parameters on fracturing fluid flowback behavior and CO₂ storage in tight formations. The results showed that CO₂ pre-fracturing increases displacement pressure and significantly improves flowback efficiency, with optimal performance achieved at a moderate injection volume. Reducing the injection rate and increasing the volume further enhanced the CO₂ storage ratio. Foam injection facilitated flowback by improving foam quality, particularly in macropores. Coinjection achieved a favorable balance between high flowback efficiency and substantial CO₂ retention. Furthermore, the three energization strategies were shown to lead to distinct fluid redistribution patterns within porous media: Pre-fracturing promoted CO₂ retention in micropores and mesopores, foam injection reduced retention in macropores, and co-injection provided the most balanced performance in mesopores. These findings provide new insights into CO₂-energized fracturing and sequestration mechanisms and offer technical guidance for optimizing CO₂-based stimulation strategies in deep unconventional tight gas reservoirs
Document Type: Original article
Cited as: Luo, K., Gao, H., Xie, Y., Ma, Z., Li, H., Cheng, Z. Assessment of CO₂-energized fracturing methods: Their impacts on fracturing fluid flowback and CO₂ geological storage in deep tight gas reservoirs. Advances in Geo-Energy Research, 2026, 19(1): 58-71. https://doi.org/10.46690/ager.2026.01.05
DOI:
https://doi.org/10.46690/ager.2026.01.05Keywords:
CO₂-energized fracturing, fracturing fluid flowback, CO₂ storage, pore-scale fluid retention, tight gas reservoirsReferences
Abdel, M., Al-Mefleh, S. K., Al-Muhanna, D., et al. Successful application of CO2 foam fracturing enables paradigm shift in stimulation strategy of North Kuwait Jurassic depleted reservoirs. Paper IPTC 23591 Presented at International Petroleum Technology Conference, Dhahran, Saudi Arabia, 12-14 February, 2024.
Agarwal, M., Kudapa, V. K. Comparing the performance of supercritical CO2 fracking with high energy gas fracking in unconventional shale. MRS Energy and Sustainability, 2022, 9: 461-468.
An, Q., Zhang, Q., Li, X., et al. Accounting for dynamic alteration effect of SC-CO2 to assess role of pore structure on rock strength: A comparative study. Energy, 2022, 260: 125125.
Chen, H., Wei, B., Zhou, X., et al. Theory and technology of enhanced oil recovery by gas and foam injection in complex reservoirs. Advances in Geo-Energy Research, 2025, 15(3): 181-184.
Cong, Z., Li, Y., Pan, Y., et al. Study on CO2 foam fracturing model and fracture propagation simulation. Energy, 2022, 238: 121778.
Edwards, R. W., Doster, F., Celia, M. A., et al. Numerical modeling of gas and water flow in shale gas formations with a focus on the fate of hydraulic fracturing fluid. Environmental Science & Technology, 2017, 51(23): 13779 13787.
Eyinla, D. S., Leggett, S., Badrouchi, F., et al. A comprehensive review of the potential of rock properties alteration during CO2 injection for EOR and storage. Fuel, 2023, 353: 129219.
Fu, J., Wie, X., Luo, S., et al. Discovery and geological knowledge of the large deep coal-formed Qingyang Gas Field, Ordos Basin, NW China. Petroleum Exploration and Development, 2019, 46(6): 1111-1126.
Gajanan, K., Ranjith, P., Yang, S., et al. Advances in research and developments on natural gas hydrate extraction with gas exchange. Renewable and Sustainable Energy Reviews, 2024, 190: 114045.
Gao, H., Luo, K., Wang, C., et al. Impact of dissolution and precipitation on pore structure in CO2 sequestration within tight sandstone reservoirs. Petroleum Science, 2025, 22(2): 868-883.
Gao, H., Wang, C., Cheng, Z., et al. Effect of pressure pulse stimulation on imbibition displacement within a tight sandstone reservoir with local variations in porosity. Geoenergy Science and Engineering, 2023a, 226: 211811.
Gao, H., Xie, Y., Cheng, Z., et al. A minireview of the influence of CO2 injection on the pore structure of reservoir rocks: Advances and outlook. Energy & Fuels, 2023b, 37(1): 118-135.
Han, B., Gao, H., Xiao, Y., et al. CO2 foam-assisted fracturing f luid flowback and CO2 sequestration in tight sandstone gas reservoirs: Experimental and numerical study. Geoenergy Science and Engineering, 2026, 257: 214199.
Harshini, R., Ranjith, P. G., Kumari, W. G. P. CO2 foam vs. conventional Methods: Enhancing deep geothermal energy recovery in extreme conditions. Renewable Energy, 2025, 256: 123905.
Iddphonce, R., Wang, J., Zhao, L. Review of CO2 injection techniques for enhanced shale gas recovery: Prospect and challenges. Journal of Natural Gas Science and Engineering, 2020, 77: 103240.
Kasala, E. E., Wang, J., Lwazi, H. M., et al. The influence of hydraulic fracture and reservoir parameters on the storage of CO2 and enhancing CH4 recovery in yanchang formation. Energy, 2024, 296: 131184.
Kim, T. H., Cho, J., Lee, K. S. Evaluation of CO2 injection in shale gas reservoirs with multi-component transport and geomechanical effects. Applied Energy, 2017, 190: 1195-1206.
Li, L., Chen, Z., Su, Y., et al. Experimental investigation on enhanced-oil-recovery mechanisms of using supercritical carbon dioxide as prefracturing energized fluid in tight oil reservoir. SPE Journal, 2021, 26(5): 3300-3315.
Luo, K., Gao, H., Wang, X., et al. Mechanism of water blocking damage in tight sandstone gas reservoirs: Novel insights from differential spectrum analysis of 2D NMR data. Measurement, 2026, 258: 119360.
Middleton, R. S., Carey, J. W., Currier, R. P., et al. Shale gas and non-aqueous fracturing fluids: Opportunities and challenges for supercritical CO2. Applied Energy, 2015, 147: 500-509.
Osselin, F., Saad, S., Nightingale, M., et al. Geochemical and sulfate isotopic evolution of flowback and produced waters reveals water-rock interactions following hydraulic fracturing of a tight hydrocarbon reservoir. Science of the Total Environment, 2019, 687: 1389-1400.
Prasad, S. K., Sangwai, J. S., Byun, H.-S. A review of the supercritical CO2 fluid applications for improved oil and gas production and associated carbon storage. Journal of CO2 Utilization, 2023, 72: 102479.
Qiao, M., Jing, Z., Zhou, R., et al. The throttling characteristics of supercritical carbon dioxide in the flowback process of CO2 fracturing. Gas Science and Engineering, 2024, 121: 205184.
Radhakrishnan, A., Chang, B., DiCarlo, D., et al. CO2 foam rheology in rough shale and sandstone fractures at elevated temperatures. Fuel, 2024, 366: 131373.
Shen, W., Ma, T., Zuo, L., et al. Advances and prospects of supercritical CO2 for shale gas extraction and geological sequestration in gas shale reservoirs. Energy & Fuels, 2024, 38(2): 789-805.
Tang, W., Zhou, F., Sheng, J. J., et al. Further investigation of CO2 energization fracturing in shale reservoir-from microscopic mechanism to field application. Fuel, 2025, 385: 134156.
Tao, Z., Wu, Y., Liu, X., et al. The synergistic mechanism of CO2 fracturing stimulation and storage of tight oil reservoirs using a cohesive zone model. Physics of Fluids, 2025, 37(8): 086631.
Wang, F., Cao, P., Wang, Y., et al. Combined effects of cyclic load and temperature fluctuation on the mechanical behavior of porous sandstones. Engineering Geology, 2020, 266: 105466.
Wang, H., Li, X., Sepehrnoori, K., et al. Calculation of the wellbore temperature and pressure distribution during supercritical CO2 fracturing flowback process. International Journal of Heat and Mass Transfer, 2019, 139: 10-16.
Wang, X., Wu, J., Zhang, J. Application of CO2 fracturing technology for terrestrial shale gas reservoirs. Natural Gas Industry, 2014, 34(1): 64-67. (in Chinese)
Xia, Y., Li, L., Wang, Z. Experimental and numerical study on influencing factors of replacement capacity and slick-water flowback efficiency using pre-CO2 fracturing in tight oil reservoirs. Journal of Petroleum Science and Engineering, 2022, 215: 110697.
Yekeen, N., Padmanabhan, E., Idris, A. K. A review of recent advances in foam-based fracturing fluid application in unconventional reservoirs. Journal of Industrial and Engineering Chemistry, 2018, 66: 45-71.
Zhao, D., Liu, Y., Ma, Z., et al. CO2 adaptive functional materials: Perspectives in geological utilization and sequestration. Advances in Colloid and Interface Science, 2026, 348: 103718.
Zhao, J., Wu, T., Pu, W., et al. Application status and research progress of CO2 fracturing fluid in petroleum engineering: A brief review. Petroleum, 2024, 10(1): 1-10.
Zheng, Y., Zhai, C., Chen, A., et al. Microstructure evolution of bituminous coal modified by high-pressure CO2 foam fracturing fluid with different treatment times. Natural Resources Research, 2023, 32(3): 1319-1338.
Zhou, H., Yan, T., Trivedi, J., et al. Investigating rock properties and fracture propagation pattern during supercritical CO2 pre-fracturing in conglomerate reservoir. Advances in Geo-Energy Research, 2025, 17(2): 95-106.
Zhou, J., Hu, N., Xian, X., et al. Supercritical CO2 fracking for enhanced shale gas recovery and CO2 sequestration: Results, status and future challenges. Advances in Geo-Energy Research, 2019, 3(2): 207-224.
Zhou, X., Li, L., Sun, Y., et al. Investigation of influence factors on CO2 flowback characteristics and optimization of flowback parameters during CO2 dry fracturing in tight gas reservoirs. Petroleum Science, 2023, 20(6): 3553-3566.
Zou, C., Li, Y., He, X., et al. Contrasting hydrocarbon reser voirs in the North China Craton in relation to inhomogeneous craton destruction. Earth-Science Reviews, 2024, 255: 104843.
Downloads
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2026 Author(s)
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.